$14.95

Download Now
Sold by service-repair-manual on Tradebit
The world's largest download marketplace
3,246,697 satisfied buyers
Shopper Award

MERCURY DOWNLOAD 2001 2002 Service Manual 115 HP 115HP EFI 4 Stroke

This 2001-2002 Mercury/Mariner Outboard Marine Service Manual/Repair Manual Covers The Following Models: 115HP (115 HP) EFI (Electronic Fuel Injection) FourStroke Engine.

The service manual download for the above listed Mercury Outboard models describes the service procedures for the complete outboard. Follow the Maintenance Schedule recommendations to ensure that the engine is in peak operating condition. Performing the scheduled maintenance is very important. It compensates for the initial wear that occurs during the life of the motor.

All chapters in the service manuals apply to the whole engine and illustrates procedures for removal & installation of components that are in detailed step-by-step fashion.

Most all service manual chapters start with an assembly or system illustration, diagrams, exploded parts view, pictures, service information and troubleshooting for the section. The subsequent pages give detailed procedures. This is a simple to download book, just like any book you would buy in a store except this book is delivered to you instantly upon purchase. No special software required as this manual works on all computers. Manual is in pdf format and delivered in pdf format.

=====================================================================
BELOW IS JUST A SMALL SAMPLE OF INFORMATION YOU MIGHT FIND IN A TYPICAL SERVICE MANUAL BUT IT COVERS EVERYTHING YOU WILL EVER NEED TO SERVICE YOUR ENTIRE MOTOR. TO MUCH INFORMATION TO LIST. INFORMATION WILL DIFFER DEPENDING ON YEAR AND MODEL
=====================================================================

SPECIFICATIONS

Some of the topics you might find in a specifications sections are Overall length Overall width Weight Transom height Recommended operating range Idle speed Engine type DOHC Number of cylinders Total displacement Spark plug Fuel supply system Multi-point sequential electronic fuel injection Exhaust system Cooling system Water cooled Lubrication system Wet sump Starting system Electric Lower Unit Fuel recommendatons Outboard Motor Gear Oil Gearcase oil capacity ml Maximum tilt angle degree Transmission Forward-Neutral-Reverse Propeller shaft rotation Propeller Right-hand rotation Propeller Counter rotation Cylinder compression Engine oil pressure Viscosity rating Engine oil amounts Oil filter change Pistion Pistion Rings Thermostat operating temperature and much more.

MAINTENANCE

In the maintenance section you will find complete maintenance specs, maintenance charts, intervals and recomendations including step by step procedures for the following: Spark plug Fuel line Replace fuel hose Breather hose Engine oil Gear oil Lubrication Anodes & Bonding wires Battery Fuel mixture check Engine oil filter Low pressure fuel filter High pressure fuel filter Ignition timing Idle speed Tappet clearance Water pump Water pump impeller Propeller nut & pin Balancer chain Bolt & Nuts Timing Belt Inspection Lubrication Points Changing Engine Oil Oil Draining Procedure Changing Oil Filter Oil Filling and much more.

GENERAL INFORMATION

The gerneral information sections will usually identify the following topics and much more: Identification Numbers Tightening Torque Service Data Specfications Cylinder Number Propellers Gas (gasoline Recomendations) 87 91 92 93 Race Gas Warm-Up Recommendations.

ELECTRICAL

The electrial sections you will find in a service manual include electrical parts holder removal and installation, and the inspection, removal, installation, troubleshooting outline of monitor tachometer starter motor, electric starter system battery charging system Disassembly Cleaning Testing Brush Replacement Reassembly Battery Charging System Manual Start Battery Charging System Tests Testing The Battery Charging Coil Testing The Battery Charging System Testing The Rectifier/Regulator.

IGNITION

A short list of some information you will find in this ignition system section include Specifications Special Tools Checking Ignition Timing Type Spark Plug Firing Order Ignition Timing Charge Coil Resistance Crank Position Sensor Resistance Ignition Coil Resistance ECM Engine Speed Limiter Spark Cut-Out Reduction ignition spark ECM Low Oil Pressure Speed Control Oil Pressure Switch and more.

CARBURETOR

If your motor carb (carburetor) than you will find everthing you need to fully adjust the carb, rebuild, remove, inspect, and clean to factory specs. Here are just a small sample you will find in service manuals where carb models apply: Specifications Special Tools Intake Carburetor Adjustments Idle Speed Linkage Choke Carburetor Removal Carburetor Disassembly Cleaning/Inspection/Repair Carburetor Reassembly Float Height Measurement Carburetor Installation Electric Choke Models InstallationIdle rpm (Out Of Gear) Idle rpm (In Forward Gear) Wide Open Throttle rpm (WOT) Main Jet Size Pilot Jet Main Jet Size Float Height 950 ± 50 rpm 850 ± 50 rpm 45005500 5200-5700 500-1000 rpm 1200-1500 rpm 1500-2000 rpm 2200 2500 rpm 3000-3500 rpm and much more.


EFI SYSTEM

A short list of some topics found in the electronic fuel injection system include Specifications Fuel Injection Nozzle Fuel Injection Pump Fuel Pump Throttle Body Throttle Control Lever and Linkage High Pressure Fuel Line High-Pressure Fuel Line Fuel Cooler Fuel Hoses Fuel Rail Pressure Regulator Idle Speed Control Assembly Intake Manifold Throttle Position Sensor Low Pressure Fuel Line/Fuel Pump Fuel Filter Fuel Pump and more.

POWERHEAD (POWER HEAD)

The powerhead section contains everthing you will need to completly rebuild your engine block back to factory specs, some information inculdes: cylinder head cover intake manifold assembly ring gear cover and air intake power unit (powerhead) measuring pump components oil pump engine lubrication system thermostat cylinder crankshaft pistion counter balancer mechanism cylinder head assembly removal inspection installation.

MID-SECTION

A quick run down of main topics in this section are engine side cover driveshaft housing and oil pan swivel bracket steering bracket and clamp wather pressure valve lower unit gear housing and all inspection removal installation cleaning assembly and reassembly procedures.

LOWER UNIT

Some of the main topics discussed in the lower unit section include gear case, propeller lower unit gears shimming and adjustment trim tab drive shaft and oil seal housing, water pump and related items, shift guide housing propeller shaft components gear bearing propeller shaft gear housing and more.


Other Chaptrs you might find in a service manual/ repair manual for your outboard motor include:

ATTACHMENTS/CONTROL LINKAGE
THROTTLE/SHIFT LINKAGE
TILLER HANDLE
MANUAL STARTER
DIAGNOSTIC TROUBLESHOOTING
WIRING DIAGRAMS

Common outboard searches:Service Manual, Repair Manual, Outboard Engine Repair, Shop Manual, Workshop Manual, Specs, Specifications, Diagrams, Exploded View, Egnine Wont Start, Engine Cranks but wont turn over, Engine starts but then shut off, engine bogs during engine overheats or is overheating fast acceleration, engine hesitates during acceleration, engine idles rough, engine is idling bad, engine idles and then shuts off, excessive smoke during idling, lots of white smoke when outboard idles, blue oil smoke during light acceleration, black smoke upon revving rev engine, motor misses while rpm speed is at tiller Handel, Manual Start, hand four stroke 4 stroke starter FourStroke 115HP (115 HP) EFI (Electronic Fuel Injection) FourStroke Engine 2001 2002 01 02.
File Data

This file is sold by service-repair-manual, an independent seller on Tradebit.

File Size 20 megabytes
File Type PDF
Customer Rating
Rated 5 out of 05, based on 14 review(s)
Our Reviews
© Tradebit 2004-2024
All files are property of their respective owners
Questions about this file? Contact service-repair-manual
DMCA/Copyright or marketplace issues? Contact Tradebit