TMitsubishi 380 2005-2007 Factory Service & Shop Manual
Complete workshop & service manual with electrical wiring diagrams for Mitsubishi 380 2005-2007. Its the same service manual used by dealers that guaranteed to be fully functional and intact without any missing page.

This Mitsubishi 380 2005-2007 service & repair manual (including maintenance, overhaul, disassembling & assembling, adjustment, tune-up, operation, inspecting, diagnostic & troubleshooting) is divided into different sections. Each section covers a specific component or system with detailed illustrations. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. The printer-ready PDF documents work like a charm on all kinds of devices.

GROUP INDEX
General . . . . . . . . . . . . . . . . . . . . . . . 00
Engine . . . . . . . . . . . . . . . . . . . . . . . . 11
Engine Lubrication . . . . . . . . . . . . . . 12
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Engine Cooling . . . . . . . . . . . . . . . . . 14
Intake and Exhaust. . . . . . . . . . . . . . 15
Engine Electrical. . . . . . . . . . . . . . . . 16
Engine and Emission Control . . . . . 17
Clutch. . . . . . . . . . . . . . . . . . . . . . . . . 21
Manual Transmission. . . . . . . . . . . . 22
Automatic Transmission . . . . . . . . . 23
Front Axle . . . . . . . . . . . . . . . . . . . . . 26
Rear Axle . . . . . . . . . . . . . . . . . . . . . . 27
Wheel and Tyre . . . . . . . . . . . . . . . . . 31
Power Plant Mount . . . . . . . . . . . . . . 32
Front Suspension . . . . . . . . . . . . . . . 33
Rear Suspension . . . . . . . . . . . . . . . 34
Service Brakes . . . . . . . . . . . . . . . . . 35
Parking Brakes . . . . . . . . . . . . . . . . . 36
Steering . . . . . . . . . . . . . . . . . . . . . . . 37
Body. . . . . . . . . . . . . . . . . . . . . . . . . . 42
Exterior . . . . . . . . . . . . . . . . . . . . . . . 51
Interior and SRS . . . . . . . . . . . . . . . . 52
Chassis Electrical . . . . . . . . . . . . . . . 54
Heater, A/C and Ventilation . . . . . . . 55
Component Locations . . . . . . . . . . . 70
Configuration Diagrams. . . . . . . . . . 80
Circuit Diagrams. . . . . . . . . . . . . . . . 90

EXCERPT:
REMOVAL SERVICE POINT
.A RADIATOR LOWER HOSE DISCONNECTION
Make mating marks on the radiator hose and the hose clamp.
Disconnect the radiator hose.
INSTALLATION SERVICE POINTS
.A THERMOSTAT INSTALLATION
CAUTION
Make absolutely sure that no oil adheres to the rubber ring of the thermostat. Also do not fold or scratch the rubber
ring during installation.
Install the thermostat so that the jiggle valve is facing straight up. Be careful not to fold or scratch the rubber ring.
.B RADIATOR LOWER HOSE CONNECTION
1. Insert each hose as far as the projection of the water inlet fitting.
2. Align the mating marks on the radiator hose and hose clamp, and then connect the radiator hose.