Contents
1 General
1 1 Introduction
1 2 General Information
1 3 Symbols in this Manual
1 4 Images in This Manual
2 Safety
2 1 Safety information
2 2 Safety and Fitting Instructions
3 Hygiene
3 1 Handling of Returned Used Products
4 Setup
4 1 General information on setup
4 2 Adjusting Seating Position
4 2 1 Adjusting Lower Leg Length
4 2 2 Adjusting Seat Depth
4 2 3 Adjusting Centre of Gravity of Seat
4 3 Adjusting Centre of Gravity ? Ultra Low Maxx Seat
4 4 Adjusting Centre of Gravity ? Modulite Seat
4 4 1 Telescopic seat frame
4 5 Adjusting Seat Height
4 5 1 Adjusting Seat Height ? Tilt with Fixed Pivot
Point
5 Testing
5 1 Testing Motor
5 2 Testing Motor Brake
5 3 Rain test
5 4 Field Load Test
5 5 Checking Battery Charge Level
6 Service
6 1 General Warning Information on Installation Work
6 2 Tightening Torques
6 3 Glossary of Frequently Used Mounting Hardware
6 4 Overview Components
6 5 Troubleshooting
6 5 1 Operational Faults
6 5 2 Drive Fault Diagnosis
6 5 3 Charging device fault diagnosis
6 6 Service Plan (Once a Year)
6 7 Shrouds
6 7 1 Power Module Shrouds
6 7 2 Water Protection Shroud
6 7 3 Main Frame Shrouds
6 7 4 Battery Shroud
6 7 5 Rear Shroud
6 7 6 Replacing Fender
6 7 7 Replacing Front Fender on Single-Sided Fork
6 7 8 Replacing Front Fender on Double-Sided Fork
6 7 9 Replacing Rim Cap and Insert (Drive Wheel)
6 7 10 Replacing Rim Cap (Castor Wheel)
6 8 Chassis
6 8 1 Changing Wheelbase
6 8 2 Replacing Kerb Climber
6 8 3 Replacing Rubber Foot
6 8 4 Replacing Tie-Down Points
6 8 5 Replacing C
6 8 6 Replacing and Adjusting Rear Suspension
6 9 Drive Components
6 9 1 Replacing Motor-Gearbox Unit
6 9 2 Replacing or rotating motor/gearbox unit sealing
ring
6 9 3 Replacing motor/gearbox clutch
6 9 4 Replacing Engaging Turn Knob
6 9 5 Replacing Castor Fork
6 9 6 Replacing Castor Lock
6 10 Wheels
6 10 1 Repair Instructions
6 10 2 Tyre Pressure
6 10 3 Tyre Types
6 10 4 Specific Tightening Torques
6 10 5 Overview of Power Wheelchair Models and
Wheel Types
6 10 6 Replacing Drive Wheel (5?Screw Installation)
6 10 7 Replacing Castor Wheel on Double-Sided Fork
6 10 8 Replacing Castor Wheels on Single-Sided Fork
6 10 9 Replacing Tyres
6 10 10 Replacing drive wheel hub
6 11 Electronics
6 11 1 Replacing Power Module
6 11 2 Replacing Bus Expansion Block (GLM-CONX4)
6 11 3 Replacing G-Trac Sensor
6 11 4 Replacing Operating Hour Counter/ Connecting
Cable
6 11 5 Replacing Cable Harness
6 11 6 Updating Software
6 12 Batteries
6 12 1 General Instructions on Handling Batteries
6 12 2 Handling Damaged Batteries Correctly
6 12 3 Making Batteries Accessible
6 12 4 Replacing Batteries
6 12 5 Replacing Circuit Breaker
6 12 6 Checking Cables
6 13 Lighting unit
6 13 1 Replacing Headlight
6 13 2 Replacing Headlight Holder
6 13 3 Replacing Rear Light
6 14 Seating
6 14 1 Replacing Actuator/Spindle ? Tilt with Fixed Pivot
Point
6 14 2 Replacing Height Adjustment Bracket ? Tilt and
Lifter-Tilt Modules
7 Mounting Dahl Docking System